Study on Properties of Iron-Rich Sludge in Pulp and Paper Industry and Its Recycling as Sludge Conditioning Agent

doi:10.7652/xjtuxb201609007

您当前的位置：

首页 >

文章列表页 >

Study on Properties of Iron-Rich Sludge in Pulp and Paper Industry and Its Recycling as Sludge Conditioning Agent

更新时间：2025-07-09

- Study on Properties of Iron-Rich Sludge in Pulp and Paper Industry and Its Recycling as Sludge Conditioning Agent
- Vol. 50, Issue 9, Pages: 43-48(2016)
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201609007
  CLC： X793;X703.1
- Online First：10 September 2016，
  
  Published：2016
- 稿件说明：
移动端阅览
Study on Properties of Iron-Rich Sludge in Pulp and Paper Industry and Its Recycling as Sludge Conditioning Agent[J]. 2016, 50(9): 43-48.
DOI：

Study on Properties of Iron-Rich Sludge in Pulp and Paper Industry and Its Recycling as Sludge Conditioning Agent[J]. 2016, 50(9): 43-48. DOI： 10.7652/xjtuxb201609007.

摘要

针对制浆造纸废水芬顿氧化过程产生的富铁污泥含铁量高的优势

及其易引起混合污泥脱水困难的问题

提出对富铁污泥进行酸处理溶出其中的Fe

以用作污泥调理剂的资源化利用新思路。采用元素分析仪、X射线荧光分析仪(XRF)和电感耦合等离子体发射光谱仪(ICP-OES)等分析富铁污泥的组成

采用X射线衍射仪(XRD)和X射线光电子能谱仪(XPS)分析富铁污泥中铁元素的存在形式; 以铁的溶出率和酸消耗量为指标优化酸处理富铁污泥的反应条件

以污泥比阻的降低程度为指标评价制得的污泥调理剂的调理效果

并与FeCl

进行对比。结果表明:富铁污泥中铁的质量分数可达39.32%

主要以三价的水合氧化铁形式存在; 常温下富铁污泥酸处理的优化条件是硫酸与绝干富铁污泥的质量比为0.91 g/g

反应时间为180 min

在此条件下铁溶出率可达57.24%。经酸处理后的富铁污泥制得的调理剂在投加量(以铁质量计)为城市污水处理厂剩余污泥干质量的3.45%时

可将污泥比阻降为其初始值的17.90%

与FeCl

的污泥调理效果相当

这说明该方法是制浆造纸厂富铁污泥资源化利用的一种可行工艺。

Abstract

Iron-rich sludge produced from the Fenton oxidation process of pulp and paper mill wastewater contains high content of iron

leading to the dewatering difficulty of the mixed sludge. To solve this problem and reuse the iron-rich sludge

an innovative approach

acidifing the iron-rich sludge to leach out Fe

as a sludge conditioning agent

was proposed in this study. The composition of iron-rich sludge was analyzed by elemental analyzer

X-ray fluorescence spectrometry(XRF)

and inductively coupled plasma optical emission spectrometry(ICP-OES). The c

hemical phase and valence of iron were determined by X-ray diffraction(XRD)and X-ray photoelectron spectroscopy(XPS). The acidification conditions were optimized according to the iron leaching rate and acid consumption. The performance of the chemical conditioning agent obtained by this approach was estimated according to the decrease of sludge specific resistance

and was compared with the conditioning performance of FeCl

. The results indicate that the iron content is 39.32% in the iron-rich sludge from a pulp and paper mill

and ferrihydrite is the main form of ferric iron. The optimal condition for acidification at room temperature is that the mass ratio of sulfuric acid to dry sludge is 0.91 g/g and the reaction time is 180 min. Under the optimal condition

57.24% of the iron in the sludge can be leached into the solution. When the dosage of conditioning agents made from iron-rich sludge reaches 3.45%(by the mass of Fe)of dry sludge

the specific resistance of excess sludge can be reduced to 17.90% of the initial value

which is quite close to the conditioning performance of FeCl

at the same dosage. The results show that this proposed method is a feasible process for the recycling of the iron-rich sludge from pulp and paper mills.

关键词

Keywords

references

葛强, 姚文峰, 雷平, 等. IC-氧化沟-Fenton法处理废纸造纸废水工程实例 [J]. 中国造纸, 2014, 33(11): 50-53.

GE Qiang, YAO Wenfeng, LEI Ping, et al. Treatment of recycled paper mill wastewater by using IC-oxidation ditch-Fenton reactor tower process [J]. China Pulp & Paper, 2014, 33(11): 50-53.

孙娟, 张维勇, 张晓琴, 等. 芬顿试剂深度处理APMP制浆废水的中试结果 [J]. 中华纸业, 2013, 34(12): 42-44.

SUN Juan, ZHANG Weiyong, ZHANG Xiaoqin, et al. Trial test project for advanced treatment of APMP pulping effluent with Fenton reagent [J]. China Pulp Paper Industry, 2013, 34(12): 42-44.

万金泉. 当代制浆造纸废水深度处理技术与实践 [J]. 中华纸业, 2011, 32(3): 18-23.

WAN Jinquan. Recent advanced treatment technology and application for pulp and paper wastewater [J]. China Pulp Paper Industry, 2011, 32(3): 18-23.

时孝磊, 朱琳, 刘晋恺, 等. Fenton/絮凝工艺深度处理制浆造纸废水的工程应用分析 [J]. 环境工程学报, 2013, 7(9): 3415-3420.

SHI Xiaolei, ZHU Lin, LIU Jinkai, et al. Application analysis of Fenton/flocculation process for advanced treatment of pulp and papermaking wastewater [J]. Chinese Journal of Environmental Engineering, 2013, 7(9): 3415-3420.

WALLING C. Fenton's reagent revisited [J]. Journal of the American Chemical Society, 1975, 97(2): 363-367.

NEYENS E, BAEYENS J. A review of classic Fenton's peroxidation as an advanced oxidation technique [J]. Journal of Hazardous Materials, 2003, 98(1/2/3): 33-50.

BENATTI C T, COSTA A C S, TAVARES C R G. Characterization of solids originating from the Fenton's process [J]. Journal of Hazardous Materials, 2009, 163(2/3): 1246-1253.

QIANG Z M, CHANG J H, HUANG C P. Electrochemical regeneration of Fe2+ in Fenton oxidation processes [J]. Water Research, 2003, 37(6): 1308-1319.

LI C W, CHEN Y M, CHIOU Y C, et al. Dye wastewater treated by Fenton process with ferrous ions electrolytically generated from iron-containing sludge [J]. Journal of Hazardous Materials, 2007, 144(1/2): 570-576.

美国水环境联合会. 城镇污水处理厂运行管理手册: 第3卷固体处理工艺 [M]. 6版. 谢丽, 何小娟, 译. 北京: 中国建筑工业出版社, 2012: 205, 256-257.

PLIEGO G, ZAZO J A, GARCIA-MUÑOZ P, et al. Trends in the intensification of the Fenton process for wastewater treatment: an overview [J]. Critical Reviews in Environmental Science and Technology, 2015, 45(24): 2611-2692.

王云海, 杨树成, 梁继东, 等. 水污染控制工程实验 [M]. 西安: 西安交通大学出版社, 2011: 84-90.

CANIZARES P, PAZ R, SAEZ C. Costs of the electrochemical oxidation of wastewaters: a comparison with ozonation and Fenton oxidation processes [J]. Journal of Environmental Management, 2009, 90(1): 410-420.

MOULDER J F, STICKLE W F, SOBOL P E, et al. Handbook of X-ray photoelectron spectroscopy [M]. Eden Prairie, Minnesota, USA: Physical Electronics Inc., 1992: 80-81.

YAMASHIT T, HAYES P. Analysis of XPS spectra of Fe2+ and Fe3+ ions in oxide materials [J]. Applied Surface Science, 2008, 254(8): 2441-2449.

BOUMAIZA H, NAILLE S, RENARD A, et al. Chemical transformation of ferrihydrite coating into green rust followed by Raman and X-ray photoelectron spectroscopies [J]. Desalination and Water Treatment, 2015, 53(4): 1031-1036.

BIESINGER M C, PAYNE B P, GROSVENOR A P, et al. Resolving surface chemical states in XPS analysis of first row transition metals, oxides and hydroxides: Cr, Mn, Fe, Co and Ni [J]. Applied Surface Science, 2011, 257(7): 2717-2730.

FRAU F, ADDARI D, ATZEI D, et al. Influence of major anions on As(V)adsorption by synthetic 2-line ferrihydrite: kinetic investigation and XPS study of the competitive effect of bicarbonate [J]. Water Air and Soil Pollution, 2010, 205(1/2/3/4): 25-41.

MCINTYRE N S, ZETARUK D G. X-ray photoelectron spectroscopic studies of iron oxides [J]. Analytical Chemistry, 1977, 49(11): 1521-1529.

郭慧. 氢氧化铁和羟基氧化铁的催化相转化机理研究 [D]. 石家庄: 河北师范大学, 2006: 3-4.

中华人民共和国住房和城乡建设部, 中华人民共和国国家发展和改革委员会. 城镇污水处理厂污泥处理处置技术指南(试行)[M]. 北京: 中国建筑工业出版社, 2012: 23-25.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Knowledge Graph Representation Learning Driven by Semantic Discrimination and Subgraph Integration

Electrothermal Coupling Research on the Evolutionary Law of Anti-Corona Performance for High-Altitude Air-Cooled Generators

Diffusion Characteristics and Influencing Factors in Case of Hydrogen Leakage from Fuel Cell Vehicles Running in Tunnels

Turbulent Kinetic Energy Dissipation Mechanism of Supercritical Carbon Dioxide Leakage Flow in a Scallop Bionic Seal Cavity

A Structure-Semantics-Residual Collaborative Image Compression Framework：Towards Privacy Protection and High-Fidelity Reconstruction

Related Author

No data

Related Institution

No data

⁰