Experimental Investigation on the Ammonia Production Process with Urea Hydrolysis for Flue Gas Denitration

doi:10.7652/xjtuxb201607007

您当前的位置：

首页 >

文章列表页 >

Experimental Investigation on the Ammonia Production Process with Urea Hydrolysis for Flue Gas Denitration

更新时间：2025-07-09

- Experimental Investigation on the Ammonia Production Process with Urea Hydrolysis for Flue Gas Denitration
- Vol. 50, Issue 7, Pages: 39-44+74(2016)
- 作者机构：
  
  西安热工研究院有限公司电站锅炉煤清洁燃烧国家工程研究中心,西安,710032
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201607007
  CLC： TK224
- Online First：10 July 2016，
  
  Published：2016
- 稿件说明：
移动端阅览
Experimental Investigation on the Ammonia Production Process with Urea Hydrolysis for Flue Gas Denitration[J]. 2016, 50(7): 39-44+74.
DOI：

Experimental Investigation on the Ammonia Production Process with Urea Hydrolysis for Flue Gas Denitration[J]. 2016, 50(7): 39-44+74. DOI： 10.7652/xjtuxb201607007.

摘要

为了掌握烟气脱硝用尿素水解制氨工艺的放大规律

通过建立中试装置来模拟工业反应器的传递过程

对尿素水解工艺开展了中试及工业化放大试验研究。结果表明

尿素溶液在一定温度、压力下发生水解反应生成氨气、二氧化碳和水蒸气的混合气

气液相平衡可采用修正的Lewis-Randall方程和Herry方程分别描述。当操作温度为150 ℃时

反应-扩散准则数M为0.036

表明尿素水解制氨为液相慢反应

本征反应速率远小于氨气扩散速率

反应器的产氨速率由动力学控制

可简化为温度和反应平衡常数的函数; 水解反应器内加热蒸汽发生冷凝换热

液相区则产生泡核沸腾; 根据中试试验数据建立的表观动力学模型

可用于指导工业反应器的结构设计。该研究将为烟气脱硝用尿素水解制氨工艺开发及反应器放大设计提供重要参考。

Abstract

In this research a pilot plant was established to simulate the transfer process in industrial reactor

and then preproduction and industrial tests were carried out. The results indicated that the urea solution was hydrolyzed to a mixture of ammonia

carbon dioxide and water vapor at certain temperature and pressure. The modified Lewis-Randall equation and Herry equation were adopted to describe the phase equilibrium between the vapor and liquid phases. When the operating temperature was 150 ℃

the reaction-diffusion criterion number M was 0.036

which indicated that the urea hydrolysis in liquid was a slow reaction and the intrinsic reaction rate was much lower than the diffusion rate of ammonia. The ammonia production rate of the reactor was dominated by dynamics and could be simplified as a function of temperature and reaction equilibrium constant. In the tank reactor

the heating steam condensed in the pipe while the nucleate boiling occurred in the liquid region. The ammonia production rates of the industrial hydrolysis reactor agreed well with the theoretical values deduced from the apparent dynamic model

and satisfied the ammonia consumption requirement for flue gas denitration in the selective catalytic reduction. This study would provide a reference to the design and development of urea hydrolysis for flue gas denitration.

关键词

Keywords

references

吕洪坤, 杨卫娟, 周俊虎, 等. 尿素溶液高温热分解特性的实验研究 [J]. 中国电机工程学报, 2010, 30(17): 35-40.

LÜ Hongkun, YANG Weijuan, ZHOU Junhu, et al. Investigation on thermal decomposition characteristics of urea solution under high temperature [J]. Proceedings of the CSEE, 2010, 30(17): 35-40.

谢红银, 熊源泉, 郑守忠, 等. 尿素/铵根溶液湿法同时脱硫脱硝特性实验研究 [J]. 西安交通大学学报, 2011, 45(12): 123-128.

XIE Hongyin, XIONG Yuanquan, ZHENG Shouzhong, et al. Experimental investigation on performance of simultaneous removal of SO2 and NOx by aqueous urea/ammonium ion solution [J]. Journal of Xi'an Jiaotong University, 2011, 45(12): 123-128.

ISLA M A, IRAZOQUI H A, GENOUD C M. Simulation of a urea synthesis reactor: 1 Thermodynamic framework [J]. Industrial Engineering Chemistry Research, 1993, 32(11): 2662-2670.

KOTULA E. A vapour-liquid equilibrium model of the NH3-CO2-H2O-urea system at elevated pressure [J]. Journal of Chemical Technology and Biotechnology, 1981, 31(1): 103-110.

张香平, 孙力, 姚平经, 等. 扩展UNIQUAC方程求NH3-CO2-H2O-(NH2)2CO体系液相活度系数的新方法 [J]. 高校化学工程学报, 2002, 16(4): 355-360.

ZHANG Xiangping, SUN Li, YAO Pingjing, et al. New approach to calculate the VLE of NH3-CO2-H2O-(NH2)2CO system with extended UNIQUAC equation [J]. Journal of Chemical Engineering of Chinese Universities, 2002, 16(4): 355-360.

沈华民. 尿素合成的化工计算: 热力学模型篇 [J]. 中氮肥, 2008(5): 1-6.

SHEN Huamin. Chemical engineering calculation on urea synthesis: section of thermodynamic model [J]. M-Sized Nitrogenous Fertilizer Progress, 2008(5): 1-6.

沈华民. 尿素合成的化工计算: 动力学模型篇 [J]. 中氮肥, 2008(6): 10-13.

SHEN Huamin. Chemical engineering calculation on urea synthesis: section of dynamic model [J]. M-Sized Nitrogenous Fertilizer Progress, 2008(6): 10-13.

MAHALIK K, SAHU J N, PATWARDHAN A V, et al. Kinetic studies on hydrolysis of urea in a semi-batch reactor at atmospheric pressure for safe use of ammonia in a power plant for flue gas conditioning [J]. Journal of Hazardous Materials, 2010, 175(1): 629-637.

SAHU J N, GANGADHARAN P, PATWARDHAN A V, et al. Catalytic hydrolysis of urea with fly ash for generation of ammonia in a batch reactor for flue gas conditioning and NOx reduction [J]. Industrial Engineering Chemistry Research, 2008, 48(2): 727-734.

SAHU J N, CHAVA V S R K, HUSSAIN S, et al. Optimization of ammonia production from urea in continuous process using ASPEN Plus and computational fluid dynamics study of the reactor used for hydrolysis process [J]. Journal of Industrial and Engineering Chemistry, 2010, 16(4): 577-586.

MAHALIK K, SAHU J N, PATWARDHAN A V, et al. Statistical modeling and optimization of hydrolysis of urea to generate ammonia for flue gas conditioning [J]. Journal of Hazardous Materials, 2010, 182(1): 603-610.

姚宣, 沈滨, 郑鹏. 烟气脱硝用尿素水解装置性能分析 [J]. 中国电机工程学报, 2013, 33(14): 38-43.

YAO Xuan, SHEN Bin, ZHENG Peng. Characteristics of urea hydrolysis equipment for flue gas denitration [J]. Proceeding of the CSEE, 2013, 33(14): 38-43.

许越. 化学反应动力学 [M]. 北京: 化学工业出版社, 2004: 12-16.

SAHU J N, MAHALIK K K, PATWARDHAN A V, et al. Equilibrium studies on hydrolysis of urea in a semi-batch reactor for production of ammonia to reduce hazardous pollutants from flue gases [J]. Journal of Hazardous Materials, 2009, 164(2): 659-664.

刘杨先, 潘剑锋, 刘勇. UV/H2O2氧化联合CaO吸收脱除NO的传质-反应动力学 [J]. 化工学报, 2013, 64(3): 1062-1068.

LIU Yangxian, PAN Jianfeng, LIU Yong. Mass transfer-reaction kinetics for NO removal by combination process of UV/H2O2 oxidation and CaO absorption [J]. CIESC Journal, 2013, 64(3): 1062-1068.

丁红蕾. 氨基湿法烟气脱硫的机理及工业试验研究 [D]. 杭州: 浙江大学, 2010.

魏顺安, 杨楠, 付雪梅, 等. 尿素溶液分离体系的汽液平衡 [J]. 化学工程, 2011, 39(11): 83-87.

WEI Shun'an, YANG Nan, FU Xuemei, et al. Vapor-liquid equilibrium of urea solution separation system [J]. Chemical Engineering, 2011, 39(11): 83-87.

RAHIMPUR M R. A non-ideal rate-based model for industrial urea thermal hydrolyser [J]. Chem Eng Process, 2004, 43(10): 1229-1307.

中国石化集团上海工程有限公司. 化工工艺设计手册 [M]. 北京: 化学工业出版社, 2003: 6-10.

高光华, 童景山. 化工热力学 [M]. 北京: 清华大学出版社, 2007: 30-36.

朱爱斌,何胜利,邹超,等.考虑接触刚度的含间隙铰接副动态磨损分析.2016,50(5):12-18.[doi:10.7652/xjtuxb201605 002]

夏凯,孙岩桦,洪德江,等.轴向拉紧的圆弧端齿轴段扭转特性研究.2016,50(5):51-56.[doi:10.7652/xjtuxb201605 008]

章云,梅雪松.机床柔性主轴转子低速无试重动平衡方法研究.2016,50(4):89-93.[doi:10.7652/xjtuxb201604014]

姚翠萍,周湘连,王晶,等.纳米金标记细胞的荧光寿命成像及其三维重建.2016,50(4):153-158.[doi:10.7652/xjtuxb 201604023]

张家旭,李静.采用自适应无迹卡尔曼滤波器的车速和路面附着系数估计.2016,50(3):68-75.[doi:10.7652/xjtuxb2016 03011]

严惠云,师义民,苏剑,等.色噪声激励下非线性随机经济周期模型及其稳定性分析.2016,50(3):141-145.[doi:10.7652/xjtuxb201603022]

严惠云,张浩磊,刘小民.一种仿生鱼体自主游动的水动力学特性分析.2016,50(2):138-144.[doi:10.7652/xjtuxb2016 02023]

陈江城,张小栋,李睿,等.利用表面肌电信号的下肢动态关节力矩预测模型.2015,49(12):26-33.[doi:10.7652/xjtuxb 201512005]

杨诏,李祥晟.高压环境下高炉煤气化学反应机理敏感性分析及机理简化.2015,49(11):39-43.[doi:10.7652/xjtuxb 201511007]

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study on the Preparation and Performance of Manganese-Based Denitration Catalyst Supported on Sponge Iron

Simulation of Heat and Mass Transfer in Solution Heat Exchanger with Hollow Fiber Membrane

Optimization for Compressor Crankshaft by Multi-Body Dynamics Analysis Method

Research on Modeling and Behavioral Characteristics of Bionic Kangaroo Leg Suspension with Circular Arc-Buffer Structures

Parameter Identification of SCARA Robot Based on Random Weight Particle Swarm Optimization

Related Author

MO Xinyu

YANG Liu

XU Hongmei

PENG Qin

WANG Zitong

SHEN Zhenxing

SONG Bo

顾兆林 2

Related Institution

School of Energy and Power Engineering, Xi'an Jiaotong University

College of Bullet Train Application and Maintenance, Dalian Jiaotong University

School of Mechanical Engineering, Taiyuan University of Science and Technology

兰州理工大学机电工程学院

(Institute of Turbomachinery, Xi'an Jiaotong University,,)

⁰