An Experimental Investigation on Hot Gas Defrost of Air-Source Transcritical CO<sub>2</sub> Heat Pump Systems

doi:10.7652/xjtuxb201503013

您当前的位置：

首页 >

文章列表页 >

An Experimental Investigation on Hot Gas Defrost of Air-Source Transcritical CO₂ Heat Pump Systems

更新时间：2025-07-09

- An Experimental Investigation on Hot Gas Defrost of Air-Source Transcritical CO₂ Heat Pump Systems
- Vol. 49, Issue 3, Pages: 74-79(2015)
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201503013
  CLC： TH327
- Online First：10 March 2015，
  
  Published：2015
- 稿件说明：
移动端阅览
An Experimental Investigation on Hot Gas Defrost of Air-Source Transcritical CO₂ Heat Pump Systems[J]. 2015, 49(3): 74-79. DOI: 10.7652/xjtuxb201503013.
DOI：

An Experimental Investigation on Hot Gas Defrost of Air-Source Transcritical CO₂ Heat Pump Systems[J]. 2015, 49(3): 74-79. DOI: 10.7652/xjtuxb201503013. DOI：

摘要

为了解决跨临界CO

热泵系统在低温环境下运行蒸发器的结霜问题

对一种可应用于CO

跨临界循环的热气除霜方法进行了实验研究。在对热气除霜过程中系统循环特性分析的基础上

搭建了空气源跨临界CO

热泵热水器实验台

根据系统各参数点压力和温度变化曲线的实验结果

分析了除霜过程中系统循环的变化规律和蒸发器的除霜特性

发现除霜时热泵系统的流量增大

气体冷却器内的温降减小

故增大气体冷却器出口的CO

气体温度是提高除霜效率的关键。同时

结合实时采集的蒸发器表面霜层变化图像

分析了蒸发器的动态除霜过程

直观观测了热气除霜的除霜效果

整个除霜过程保持了600 s

热气除霜的除霜效率为35.6%。根据实验结果可以得出

热气除霜方法是用于空气源跨临界CO

热泵系统除霜切实可行的方法。

Abstract

A hot gas defrosting method is investigated to solve the frost accumulation on the finned tube evaporator for transcritical CO

heat pump systems. It is based on the analysis of defrost cycle process

and an air-source transcritical CO

heat pump water heater test rig is built in an environmental laboratory. Based on the experimental results of the pressure and temperature variations that the defrost cycle process and defrosting characteristic in the evaporator are discussed

and it is found that the mass flow rate increases and the temperature difference between gas cooler inlet and outlet decreases during the defrosting process. It is also found that the key to

improve the defrost efficiency is to increase the gas cooler outlet temperature of CO

gas. Meanwhile

instant defrosting pictures of evaporator surface are captured to record the dynamic defrosting process and to evaluate the defrost effect of hot gas defrosting. The whole defrosting process maintains 600 s and the defrosting efficiency of the hot gas defrosting method is 35.6%. It can be concluded from the experimental results that the hot gas defrosting method is a reasonable and practicable method for CO

heat pump systems.

关键词

Keywords

references

LORENTZEN G. Revival of carbon dioxide as a refrigerant [J]. International Journal of Refrigeration, 1994, 17(5): 292-300.

NEKSA P. CO2 heat pump water heater characteristics, system design and experimental results [J]. International Journal of Refrigeration, 1998, 21(3): 172-179.

KOMDEPUDI S N, O'NEAL D L. Effect of frost growth on the performance of louvered finned tube heat exchangers [J]. International Journal of Refrigeration, 1989, 12(1): 151-158.

O'NEAL D L, KATIPAMULA S. Effect of short-tube orifice size on the performance of an air source heat pump during the reverse-cycle defrosts [J]. International Journal of Refrigeration, 1991, 14(3): 52-58.

CHO H, KIM Y, JANG I. Performance of a showcase refrigeration system with multi-evaporator during on-off cycling and hot-gas by pass defrost [J]. Energy, 2005, 30(10): 1915-1930.

BYUN J, LEE J, JEON C D. Frost retardation of an air-source heat pump by the hot gas bypass method [J]. International Journal of Refrigeration, 2008, 31(1): 328-334.

HOFFENBECKER N, KLEIN S A, REINDL D T. Hot gas defrost model development and validation [J]. International Journal of Refrigeration, 2005, 28(1): 605-615.

黄东, 袁秀玲. 风冷热泵冷热水机组热气旁通除霜与逆循环除霜性能对比 [J]. 西安交通大学学报, 2006, 40(5): 539-543.

HUANG Dong, YUAN Xiuling. Comparison of dynamic characteristics between the hot-gas bypass defrosting method and reverse-cycle defrosting method on an air-to-water heat pump [J]. Journal of Xi'an Jiaotong University, 2006, 40(5): 539-543.

HU W J, JIANG Y Q, QU M L, et al. An experimental study on the operating performance of a novel reverse-cycle hot gas defrosting method for air source heat pumps [J]. Applied Thermal Engineering, 2011, 31(1): 363-369.

DONG J K, DENG S M, JIANG Y G, et al. An experimental investigation on reverse-cycle defrosting performance for an air source heat pump using an electronic expansion valve [J]. Applied Thermal Engineering, 2012, 97(1): 327-333.

DONG J K, DENG S M, JIANG Y G, et al. An experimental study on defrosting heat supplies and energy consumptions during a reverse cycle defrost operation for an air source heat pump [J]. Applied Thermal Engineering, 2012, 37(5): 380-387.

KWAK K, BAI C. A study on the performance enhancement of heat pump using electric heater under the frosting condition: heat pump under frosting condition [J]. Applied Thermal Engineering, 2010, 30(6/7): 539-543.

MELO C, KNABBEN F T, PEREIRA P V. An experimental study on defrost heaters applied to frost-free household refrigerators [J]. Applied Thermal Engineering, 2013, 51(1/2): 239-245.

LIANG C H, ZHANG X S, LI X W, et al. Control strategy and experimental study on a novel defrosting method for air-source heat pump [J]. Applied Thermal Engineering, 2010, 30(8/9): 889-892.

MILDENBERGER J. R744 two-phase natural circu-lation for heat pump defrosting [EB/OL]. [2014-06-04]. http:∥www.r744.com/assets/link/1_abstract_mildenberger.

MINETTO S. Theoretical and experimental analysis of a CO2 heat pump for domestic hot water [J]. International Journal of Refrigeration, 2011, 34(3): 742-751.

HU Bin, WANG Xiaolin, CAO Feng, et al. Experimental analysis of an air-source transcritical CO2 heat pump water heater using the hot gas bypass defrosting method [J]. Applied Thermal Engineering, 2014, 71(1): 528-535.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study on the Thermodynamic Properties in the Anomalous Region of Supercritical Water

A Structure-Semantics-Residual Collaborative Image Compression Framework：Towards Privacy Protection and High-Fidelity Reconstruction

Review of the Application of EBSILON Software in Combined Heat and Power System Optimization

Knowledge Graph Representation Learning Driven by Semantic Discrimination and Subgraph Integration

Effects of Steam Addition on the Swirl Combustion and Emission Characteristics of Cracked Ammonia

Related Author

No data

Related Institution

No data

⁰

An Experimental Investigation on Hot Gas Defrost of Air-Source Transcritical CO2 Heat Pump Systems

DOI：10.7652/xjtuxb201503013

摘要

Abstract

关键词

Keywords

references

An Experimental Investigation on Hot Gas Defrost of Air-Source Transcritical CO₂ Heat Pump Systems