Combustion Performance and Stability in Dual Fuel Engine with Different Pilot Diesel Injection Timings

doi:10.7652/xjtuxb201407006

您当前的位置：

首页 >

文章列表页 >

Combustion Performance and Stability in Dual Fuel Engine with Different Pilot Diesel Injection Timings

更新时间：2025-07-09

- Combustion Performance and Stability in Dual Fuel Engine with Different Pilot Diesel Injection Timings
- Vol. 48, Issue 7, Pages: 29-33+130(2014)
- 作者机构：
  
  西安交通大学内燃机研究所,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201407006
  CLC： TK474.7
- Online First：10 July 2014，
  
  Published：2014
- 稿件说明：
移动端阅览
Combustion Performance and Stability in Dual Fuel Engine with Different Pilot Diesel Injection Timings[J]. 2014, 48(7): 29-33+130.
DOI：

Combustion Performance and Stability in Dual Fuel Engine with Different Pilot Diesel Injection Timings[J]. 2014, 48(7): 29-33+130. DOI： 10.7652/xjtuxb201407006.

摘要

针对天然气、柴油双燃料发动机

研究了不同引燃油提前角下双燃料发动机的燃烧和循环变动特性。结果表明:给定引燃油量

喷油提前角提前

缸内最大压力增大

缸内最大压力出现时刻提前; 双燃料发动机的放热率特性曲线存在2个波峰

喷油提前角提前有助于引燃柴油完全燃烧

使得引燃能量更大

整体混合气燃烧更充分

放热持续时间缩短

放热速度加快; 随着喷油提前角的提前

缸内最大压力和最大压升率显著增大

缸内最大压力的循环变动的变化不明显

最大压升率的循环变动的变化显著; 缸内最大压力和平均指示压力与缸内最大压力对应的曲轴转角密切相关且随喷油提前角的提前向上止点移动

缸内最大压升率与其对应曲轴转角的相关性随着喷油提前角的提前而削弱; 随着喷油提前角的提前

最大压力和平均指示压力的循环变动系数减小

喷油提前角为20°时最大压力循环变动系数最大

为5.4%

给定喷油提前角下平均指示压力的循环变动系数均小于4%。

Abstract

The combustion performance and stability of a dual fuel engine fueled with diesel and natural gas at different pilot diesel injection timings are investigated. The results show that the profile of in-cylinder pressure is advanced

the peak pressure gets greater and appears earlier

and there exist two peaks of heat release rate in dual fuel engine; the advanced pilot diesel injection timing facilitates complete combustion of pilot diesel to supply more ignition power; the whole heat release rate is elevated with earlier pilot diesel injection timing; the peak pressure and the maximum rate of pressure rise increase dramatically with the earlier pilot diesel injection timing

the change of the cyclic variation of peak pressure is unconspicuous

while the change of the cyclic variation of the maximum rate of pressure rise increases with earlier injection timing. The peak pressure and indicated mean effective pressure show a correlation with the crank angle corresponding to peak pressure

the distribution moves towards the top dead center with earlier pilot diesel injection timing

and the interdependence of maximum rate of pressure rise and its corresponding crank angle is weakened. The cyclic variations get the maximum(5.4%)at 20° before top dead center. The cyclic variations of indicated mean effective pressure are all bellow 4%.

关键词

Keywords

references

尧命发. “均质压燃、低温燃烧”新一代内燃机技术[J]. 内燃机, 2012, 4(2): 1-4.

YAO Mingfa. New combustion technology on homogeneous charge compression ignition and low temperature combustion[J]. Internal Combustion Engines, 2012, 4(2): 1-4.

CORDINER S, GAMBINO M, IANNACCONE S, et al. Numerical and experimental analysis of combustion and exhaust emissions in a dual-fuel diesel/natural gas engine[J]. Energy Fuels, 2008, 22(3): 1418-1424.

WEAVER C S, TURNER S H. Dual fuel natural gas/diesel engines: technology, performance, and emissions, SAE940548[R]. Washington DC, USA: SAE, 1994.

SRINIVASAN K K, KRISHNAN S R, MIDKIFF K C. Improving low load combustion, stability, and emissions in pilot-ignited natural gas engines[J]. Proc Inst Mech Eng: Part D Journal of Automobile Engineering, 2006, 220(D): 229-239.

SRINIVASAN K K, KRISHNAN S R, SINGH S, et al. The advanced injection low pilot ignited natural gas engine: a combustion analysis[J]. ASME Journal of Engineering Gas Turbines Power, 2006, 128(1): 213-218.

HEYWOOD J B. Internal combustion engine fundamentals[M]. New York, USA: McGraw-Hill, 1988.

林志强, 苏万华, 万国强. 柴油引燃天然气发动机着火特性及其影响因素的影响[J]. 燃烧科学与技术, 2003, 9(3): 234-238.

LIN Zhiqiang, SU Wanhua, WANG Guoqiang. Study on characteristics of ignition and misfire in the diesel/natural gas dual fuel engine[J]. Journal of Combustion Science and Technology, 2003, 9(3): 234-238.

林志强, 苏万华. 柴油引燃式天然气发动机最佳引燃柴油量及过量空气系数浓限、稀限的研究[J]. 内燃机学报, 2002, 2(6): 505-510.

LIN Zhiqiang, SU Wanhua. A Study on determination of amount of pilot injection and rich and lean boundaries of premixed CNG/air mixture for a CNG/diesel dual fuel engine[J]. Transactions of CSICE, 2002, 20(6): 505-510.

YAO Chunde, YAO Guangtao, SONG Jin'ou, et al. A theoretical study on the realization of QHCCI in a pre-mixed natural gas engine ignited by pilot diesel fuel[J]. Automotive Engineering, 2005, 27(2): 168-171.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Cycle-by-Cycle Variations of a Diesel Pilot-Ignited Natural Gas Engine with Exhaust Gas Recirculation

Performance and Emission of Diesel Engine Operating on Diesel-Propane Blends

Effects of Fuel Injection Timing on Combustion and Emission Characteristics of a Diesel Engine Fuelled with Diesel-Propane Blends

The Development of a Dual Fuel Engine Electronic Control Unit and Control Strategy

Investigation of Dimethyl Ether Injection Process and Influencing Factors

Related Author

曾科

周磊

苗海燕 1

王锡斌 1

李冲霄 1

黄佐华 1

马志豪 1

Related Institution

Institute of Internal Combustion Engine, Xi'an Jiaotong University

西安交通大学动力工程多相流国家重点实验室

河南科技大学车辆与动力工程学院

江苏女神汽车集团

State Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University

⁰