Special Cross-Under Pipe Separators Structure and Moisture Separation Performance of Nuclear Power Steam Turbines

doi:10.7652/xjtuxb201405011

您当前的位置：

首页 >

文章列表页 >

Special Cross-Under Pipe Separators Structure and Moisture Separation Performance of Nuclear Power Steam Turbines

更新时间：2025-07-09

- Special Cross-Under Pipe Separators Structure and Moisture Separation Performance of Nuclear Power Steam Turbines
- Vol. 48, Issue 5, Pages: 61-66+77(2014)
- 作者机构：
  
  西安交通大学叶轮机械研究所,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201405011
  CLC： TK263
- Online First：10 May 2014，
  
  Published：2014
- 稿件说明：
移动端阅览
Special Cross-Under Pipe Separators Structure and Moisture Separation Performance of Nuclear Power Steam Turbines[J]. 2014, 48(5): 61-66+77.
DOI：

Special Cross-Under Pipe Separators Structure and Moisture Separation Performance of Nuclear Power Steam Turbines[J]. 2014, 48(5): 61-66+77. DOI： 10.7652/xjtuxb201405011.

摘要

为了提高弯管式汽水分离器的除湿效率

提出了2种汽水分离器改进结构

一种是弯管前加旋流装置的组合分离器

另一种是“Z”字形弯管分离器

同时对改进结构进行了数值研究。结果表明:弯管前加旋流装置的组合分离器中

汽流经过旋流叶栅后流向发生偏转

紊乱的流场持续到第一组导流除湿叶栅进口

汽流经过第二组导流除湿叶栅后流线基本与圆管的轴向一致

汽流经过旋流叶栅和导流除湿叶栅时会产生较大总压损失; “Z”字形弯管分离器管中

汽相流速比较均匀

流线分布良好

总压损失主要发生在导流除湿叶栅中。与弯管式分离器相比

弯管前加旋流装置的组合分离器的除湿效率提高了7.4%

平均总压损失系数增大了28.1%; “Z”字形弯管分离器性能最佳

除湿效率提高了11.3%

平均总压损失系数减小了37.5%。该结果可为研究和开发新型汽水分离器提供理论依据。

Abstract

To improve the moisture separation efficiency of special cross-under pipe separators(SCRUPS)

two modified separators — combinational separator with a swirl device in front of SCRUPS and “Z” shaped SCRUPS are proposed and numerically investigated. The results show that steam in combinational separator deflects after the swirl blades

and its disordered flow continues to the inlet of the first row of blade cascade and gets homogeneous after the second row. Considerable total pressure loss occurs in swirl blades and blades cascades. Relatively homogeneous steam velocity and fine streamline distribution appear in “Z” shaped separator

and the total pressure loss occurs mainly in blade cascades. Compared with SCRUPS

the combinational separator enhances the moisture separation efficiency by 7.4% and the average total pressure loss coefficient by 28.1% relatively

and the “Z” shaped separator is endowed with the best performance

where the moisture separation efficiency is increased by 11.3%

and the average total pressure loss coefficient is decreased by 37.5%.

关键词

Keywords

references

李亮, 王华, 游玮, 等. 核电汽轮机汽水分离再热器的发展现状[C]∥中国动力工程学会透平专业委员会2011年学术研讨会论文集. 北京: 中国动力工程学会, 2011.

VON BOECKH P, STIEFEL M, FRICK U. Experience with the moisture preseparator(MOPS)and with the special crossunder pipe separator(SCRUPS)in the Leibstadt nuclear plant[C]∥Proceedings of American Power Conference. Baden, USA: BBC Brown Boveri and Co. Ltd., 1986: 860422.

LEMEZIS S, BUSHEY J R, RABAS T J. Operating experience with new moisture pre-separators and special crossunder pipe separators[J]. ABB Review, 1990, 3(1): 3-10.

DROSDZIOK A, FELDMUELLER A, HAM D, et al. Steam turbine and steam power plant with the steam turbine: Switzerland, WO1998016724 A1[P]. 1998-04-23.

JR SILVESTRI G J. Water collector for steam turbine exhaust system: USA, US4825653 A[P]. 1989-05-02.

朱东琦. 波形板汽水分离器中流场的数值模拟[D]. 哈尔滨: 哈尔滨工程大学, 2004.

任水强. 核电汽轮机弯管式汽水分离器的去湿特性数值分析[D]. 西安: 西安交通大学, 1996.

柯华, 明廷臻, 涂正凯. 旋流叶片传热管内湍流强化传热数值模拟[J]. 冶金能源, 2009, 28(2): 38-41.

KE Hua, MING Tingzhen, TU Zhengkai. Numerical simulation of turbulent heat transfer enhancement in the heat transfer tube with swirling blades[J]. Energy for Metallurgical Industry, 2009, 28(2): 38-41.

PARKER G J, LEE P. Studies of the deposition of sub-micron particles on turbine blades[J]. Proceedings of the Institution of Mechanical Engineers, 1972, 186(1): 519-526.

邓建中, 刘之行. 计算方法[M]. 2版. 西安: 西安交通大学出版社, 2001.

陈静涛, 孙祖基, 张志新. 湿蒸汽汽轮机高压缸排汽中水滴平均直径的计算[J]. 汽轮机技术, 1998, 40(2): 92-95.

CHEN Jingtao, SUN Zuji, ZHANG Zhixin. The average diameter calculation of drops in wet steam turbine's high-pressure cylinder exhaust gas[J]. Turbine Tech-nology, 1998, 40(2): 92-95.

GYARMATHY G, BURKHARD H P, LESCH F, et al. Spontaneous condensation of steam at high pressure: first experimental results[C]∥Proc Inst Mech Engr Conf. London, UK: IME, 1973: 197-208.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical Investigations on Nonaxisymmetrical End Wall Profiling and Aerodynamic Performance of a Low Aspect Ratio Cascade

Numerical Investigations for Mechanism of Pre-Ignition Induced by Lubricant Oil Droplets in Supercharged DISI Engines

Numerical Investigation for Coupled Flow Behavior Between Gas Flow and Wall Film of Flat and Turbine Stator

Numerical Investigation on Effects of Leakage Flow on the Aerodynamic Performance of Turbine Stages

Study on the Thermodynamic Properties in the Anomalous Region of Supercritical Water

Related Author

丰镇平

李军

宋立明

孙皓

陈锐 2

张文嘉 1

孟凡胜 1

黄勇成 1

Related Institution

School of Energy and Power Engineering, Xi'an Jiaotong University

西安交通大学能源与动力工程学院

东方汽轮机有限公司产品研发中心

⁰