Effect of Adding Oxygenated Fuel on Particles Emissions of Pilot-Ignited Natural Gas Engine

doi:10.7652/xjtuxb201401004

您当前的位置：

首页 >

文章列表页 >

Effect of Adding Oxygenated Fuel on Particles Emissions of Pilot-Ignited Natural Gas Engine

更新时间：2025-07-09

- Effect of Adding Oxygenated Fuel on Particles Emissions of Pilot-Ignited Natural Gas Engine
- Vol. 48, Issue 1, Pages: 19-24(2014)
- 作者机构：
  
  1. 西安交通大学能源与动力工程学院,西安,710049
  2. 吉利汽车动力总成研究院,浙江,宁波,715336
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201401004
  CLC： TK431
- Online First：10 January 2014，
  
  Published：2014
- 稿件说明：
移动端阅览
Effect of Adding Oxygenated Fuel on Particles Emissions of Pilot-Ignited Natural Gas Engine[J]. 2014, 48(1): 19-24.
DOI：

Effect of Adding Oxygenated Fuel on Particles Emissions of Pilot-Ignited Natural Gas Engine[J]. 2014, 48(1): 19-24. DOI： 10.7652/xjtuxb201401004.

摘要

为了降低柴油引燃天然气发动机的颗粒排放

在改装的柴油机上试验研究了含氧燃料碳酸二甲酯(DMC)添加对柴油引燃天然气发动机燃烧和颗粒排放的影响。通过对比分析不同的含氧燃料掺混比下的燃烧参数和颗粒排放特性发现:随着引燃燃料中DMC掺混比的增大

引燃燃料中含氧量(氧的质量分数)的不断增加

滞燃期逐渐推迟

初始燃烧放热率峰值增大

初始燃烧期逐渐延长

总燃烧持续期不断缩短; 柴油引燃天然气发动机的颗粒排放呈现单峰分布

随着引燃燃料中含氧量的增加

颗粒数量浓度峰值粒径向大颗粒粒径方向移动

颗粒的数量浓度和质量浓度同时减小

当引燃燃料中含氧量达20%时

颗粒质量浓度降幅达70%

颗粒数量浓度降幅达86%。因此

引燃燃料中添加含氧燃料DMC是一种降低柴油引燃天然气发动机颗粒排放的有效方法。

Abstract

In order to reduce particles emissions of diesel pilot-ignited natural gas engines

the combustion and the particles emissions were experimentally investigated on a pilot-ignited natural gas engine using diesel-dimethyl carbonate(DMC)as the pilot fuel

and the corresponding combustion and emissions characteristics were also analyzed. The results show that an increase in the proportion of DMC in the pilot fuel can increase the oxygen content of pilot fuel

extend the ignition delay period

increase the peak of initial combustion rate and initial combustion period

and shorten the total combustion duration. The particle size distribution is all unimodal. With the increase in the oxygen content of pilot fuels

the peak of particle number concentration moves towards the larger particle size

and the particle number concentration and the particle mass concentration decrease simultaneously. The particle number concentration and the particle mass concentration decrease by up to 70% and 86%

respectively

at the oxygenate mass of 20% in pilot mass and a special load. These results indicate that adding DMC to the pilot fuel is an effective method for reducing particles emissions of diesel pilot-ignited natural gas engines.

关键词

Keywords

references

BP Company. BP statistical review of world energy[EB/OL].[2013-02-20]. http:∥www.bp.com/liveassets/bp_internet/globalbp/globalbp_uk_english/reports_and_publications/statistical_energy_review_2011/STAGING/local_assets/pdf/statistical_review_of_world_energy_full_report_2012.pdf.2012.7.

SRINIVASAN K K, KRISHNAN S R, MIDKIFF K C. Improving low load combustion, stability and emissions in pilot-ignited natural gas engines[J]. Proceedings of IMechE: Part D Journal of Automobile Engineering, 2006, 220(2): 229-239.

PAPAGIANNAKIS R G, HOUNTALAS D T. Combustion and exhaust emission characteristics of a dual fuel compression ignition engine operated with pilot diesel fuel and natural gas[J]. Energy Conversion and Management, 2004, 45(18/19): 2971-2987.

姚春德, 刘增勇, 高昌卿. 柴油引燃预混天然气准均质压燃着火过程的研究[J]. 内燃机学报, 2003, 21(1): 7-12.

YAO Chunde, LIU Zengyong, GAO Cangqin. Mechanism on distribution of pilot fuel spray and compressing ignition in premixed natural gas engine ignited by pilot diesel[J]. Transactions of CSICE, 2003, 21(1): 7-12.

ZHOU L, LIU Y, SUN L, et al. Effect of hot exhaust gas recirculation on the combustion characteristics and particles emissions of a pilot-ignited natural gas engine, SAE 2013-01-1341[R]. Washington DC, USA: SAE, 2013.

LU X C, YANG J G, ZHANG W G, et al. Improving the combustion and emissions of direct injection compression ignition engines using oxygenated fuel additives combined with a cetane number improver[J]. Energy Fuels, 2005, 19(5): 1879-1888.

ZHAO X, REN M, LIU Z. Critical solubility of dimethyl ether diesel fuel and dimethyl carbonate diesel fuel[J]. Fuel, 2005, 84(18): 2380-2383.

HUANG Z H, JIANG D M, ZENG K, et al. Combustion characteristics and heat release analysis of a direct injection compression ignition engine fuelled with diesel-dimethyl carbonate blends[J]. Proceedings of the Institution of Mechanical Engineers: Part D Journal of Automobile Engineering, 2003, 217(D7): 595-605.

ARTECONI A, MAZZARINI A, DI NICOLA G. Emissions from ethers and organic carbonate fuel additives: a review[J]. Water Air and Soil Pollution, 2011, 221(1/2/3/4): 405-423.

CHEUNG C S, ZHU R J, HUANG Z H. Investigation on the gaseous and particulate emissions of a compression ignition engine fueled with diesel-dimethyl carbonate blends[J]. Science of the Total Environment, 2011, 409(3): 523-529.

ISHIYAMA T, KANG J, OZAWA Y, et al. Improvement of performance and reduction of exhaust emissions by pilot-fuel-injection control in a lean-burning natural-gas dual-fuel engine[J]. SAE International Journal of Fuels Lubrication, 2011, 5(1): 243-253.

AZIMOV U, TOMITA E, KAWAHARA N, et al. Premixed mixture ignition in the end-gas region(PREMIER)combustion in a natural gas dual-fuel engine: operating range and exhaust emissions[J]. International Journal of Engine Research, 2011, 12(5): 484-497.

TSOLAKIS A, HERNANDEZ J J, MEGARITIS A, et al. Dual fuel diesel engine operation using H2. effect on particulate emissions[J]. Energy Fuels, 2005, 19(2): 418-425.

林志强, 苏万华, 王国祥. 柴油引燃天然气发动机着火特性及其影响因素的研究[J]. 燃烧科学与技术, 2003, 9(3): 234-238.

LIN Zhiqiang, SU Wanhua, WANG Guoxiang. Study of characteristics of ignition and misfire in the diesel/natural gas dual fuel engine[J]. Journal of Combustion Science and Technology, 2003, 9(3): 234-238.

KITTELSON D B. Engines and nanoparticles: a review[J]. Journal of Aerosol Science, 1998, 29(5/6): 575-588.

SCHNEIDER J, HOCK N, WEIMER S, et al. Nucleation particles in diesel exhaust: composition inferred from in situ mass spectrometric analysis[J]. Environmental Science Technology, 2005, 39(16): 6153-6161.

LI Z, SONG C L, SONG J O, et al. Evolution of the nanostructure, fractal dimension and size of in-cylinder soot during diesel combustion process[J]. Combustion and Flame, 2011, 158(8): 1624-1630.

刘炜, 黄震. 不同燃烧模式下正庚烷燃烧发动机排气超细颗粒特性[J]. 上海交通大学学报, 2011, 45(6): 837-841.

LIU Wei, HUANG Zhen. Effects of combustion modes on exhaust particle size distributions from a diesel engine fueled with n-Heptane[J]. Transactions of CSICE, 2003, 45(6): 837-841.

姚春德, 张志辉, 张丰顺. 柴油甲醇组合燃烧发动机的微粒排放及催化转化特性[J]. 内燃机学报, 2010, 28(6): 494-499.

YAO Chunde, ZHANG Zhihui, ZHANG Fengshun. Emissions and oxidation characteristics of particulate from a diesel/methanol compound combustion engine[J]. Transactions of CSICE, 2010, 28(6): 494-499.

孙璐,刘亦夫,周磊,等.排气再循环下柴油引燃天然气发动机循环变动特性研究.2013,47(3):36-41.[doi:10.7652/xjtuxb201303007]

刘亦夫,刘兵,刘亮,等.天然气缸内直喷发动机在不同喷射和点火时刻下的排放与燃烧特性.2011,45(5):12-16.[doi:10.7652/xjtuxb201105003]

姜雪,胡二江,巩静,等.天然气掺氢配合废气再循环发动机的性能及排放研究.2009,43(5):18-21.[doi:10.7652/xjtuxb200905004]

王婕,黄佐华,刘兵.天然气掺氢配合废气再循环发动机燃烧过程的数值模拟.2009,43(5):22-25.[doi:10.7652/xjtuxb 200905005]

魏衍举,汪文瑞,黄瑾,等.柴油机颗粒物可溶有机组分来源研究.2013,43(5):6-11.[doi:10.7652/xjtuxb201305002]

刘兵,黄佐华,曾科,等.天然气掺氢火花点火式发动机排放性能研究.2008,42(2):243-247.[doi:10.7652/xjtuxb2008 02026]

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical Simulation of Combustion Process in a Spark-Ignition Engine Fuelled with Natural Gas-Hydrogen Blends Combined with Exhaust Gas Recirculation

Polycyclic Aromatic Hydrocarbons from a Gasoline Direct Injection Engine During Start

Low-Speed Performance Improvement of Natural Gas Engine by Asynchronous Intake Timing and Turbocharger Matching

Effects of Hydrogen-Rich Reformed Gas on the Combustion Reaction Process in a Natural Gas Engine

Influence of Injection Strategy on Combustion and Emissions of Multi-point Injection Natural Gas Engine

Related Author

刘兵

黄佐华

王婕

袁超 1

洪伟 1

苏岩 1

Related Institution

State Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University

吉林大学汽车仿真与控制国家重点实验室

吉林大学汽车工程学院

一汽铸造有限公司

School of Energy and Power Engineering, Wuhan University of Technology

⁰