Cycle-by-Cycle Variations of a Diesel Pilot-Ignited Natural Gas Engine with Exhaust Gas Recirculation

doi:10.7652/xjtuxb201303007

您当前的位置：

首页 >

文章列表页 >

Cycle-by-Cycle Variations of a Diesel Pilot-Ignited Natural Gas Engine with Exhaust Gas Recirculation

更新时间：2025-07-09

- Cycle-by-Cycle Variations of a Diesel Pilot-Ignited Natural Gas Engine with Exhaust Gas Recirculation
- Vol. 47, Issue 3, Pages: 36-41(2013)
- 作者机构：
  
  西安交通大学内燃机研究所,西安,701149
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201303007
  CLC： TK474.7
- Online First：10 March 2013，
  
  Published：2013
- 稿件说明：
移动端阅览
Cycle-by-Cycle Variations of a Diesel Pilot-Ignited Natural Gas Engine with Exhaust Gas Recirculation[J]. 2013, 47(3): 36-41.
DOI：

Cycle-by-Cycle Variations of a Diesel Pilot-Ignited Natural Gas Engine with Exhaust Gas Recirculation[J]. 2013, 47(3): 36-41. DOI： 10.7652/xjtuxb201303007.

摘要

在柴油引燃天然气发动机上开展了结合排气再循环(EGR)的循环变动特性研究

分析了不同EGR率和引燃油量下的循环变动规律。结果表明:在给定的引燃油量下

随着EGR率的增加

燃烧循环变动增强

缸内平均最大压力和平均指示压力下降

缸内最大压力和平均指示压力与缸内最大压力对应的曲轴转角之间的相关性减弱; 引入EGR

缸内最大压力升高率减小

与曲轴转角之间的相关性减弱

燃烧速率下降; EGR率与循环变动系数呈非线性关系。输出扭矩不同

引燃油量对循环变动特性的影响不同

低负荷下过高和过低的引燃油量均会使得缸内平均指示压力循环变动加剧

负荷升高时引燃油量对循环变动系数的影响不太明显。

Abstract

Cycle-by-cycle variations of a pilot-ignited natural gas engine with EGR(exhaust gas recirculation)were examined. The effects of EGR ratio and pilot diesel quantity on cyclic variation characteristics were analyzed. The results show that when the cycle-by-cycle variations increase

the maximum average pressure decreases

and the indicated mean effective pressure decreases with an increase in the EGR ratio at a given pilot diesel quantity. Moreover

the weak interdependence occurs between the parameters above and their corresponding crank angles with an increase in the EGR ratio. The use of the EGR leads to the decrease in the burning rate and the maximum rate of pressure rise drops with the increase in the EGR ratio. The cycle-by-cycle variations change nonlinearly with the EGR ratio. At different loads

the pilot quantity has different influence on the cycle-by-cycle variations. Over-high or over-low pilot diesel quantity increases the cycle-by-cycle variations at the low load. The effect of the pilot quantity on the cycle-by-cycle variations is slight when the load is high.

关键词

Keywords

references

姚春德, 刘增勇, 高昌卿. 柴油引燃预混天然气准均质压燃着火过程的研究 [J]. 内燃机学报, 2003, 21(1): 8-12

YAO Chunde, LIU Zengyong, GAO Changqing. Study on HCCI of pre-mixed natural gas ignited by pilot diesel [J]. Transactions of CSICE, 2003, 21(1): 8-12.

SRINIVASAN K K, KRISHNAN S R, MIDKIFF K C. Improving low load combustion, stability, and emissions in pilot-ignited natural gas engines [J]. Automobile Engineering, 2006, 20(D): 229-239.

MCTAGGART-COWAN G P, BUSHE W K. A supercharged heavy-duty diesel single-cylinder research engine for high-pressure direct injection of natural gas [J]. International Journal of Engine Research, 2003, 4(4): 315-330.

YAO Chunde, YAO Guangtao, SONG Jin'ou, et al. A theoretical study on the realization of QHCCI in a pre-mixed natural gas engine ignited by pilot diesel fuel [J]. Automotive Engineering, 2005, 27(2): 168-171.

林志强, 苏万华. 柴油引燃式天然气发动机最佳引燃柴油量及过量空气系数浓限、稀限的研究 [J]. 内燃机学报, 2002, 20(6): 505-510.

LIN Zhiqiang, SU Wanhua. A study on determination of amount of pilot injection and rich and lean boundaries of premixed CNG/air mixture for a CNG/diesel dual fuel engine [J]. Transactions of CSICE, 2002, 20(6): 505-510.

HEYWOOD J B. Internal combustion engine fundamentals [M]. New York, USA: McGraw-Hill, 1988.

刘亮欣, 黄佐华, 蒋德明, 等. 天然气缸内直喷发动机燃烧循环变动特性研究 [J]. 内燃机学报, 2005, 23(1): 18-27.

LIU Liangxin, HUANG Zuohua, JIANG Deming, et al. Study on cycle-by-cycle variations in a direct injection natural gas engine [J]. Transactions of CSICE, 2005, 23(1): 18-27.

BEN L, CHARNAY G, TRUGUEST R. Influence of air/fuel ratio on cyclic variation and exhaust emission in natural gas SI engine, SAE 992901 [R]. Washington DC, USA: SAE, 1999.

李兴虎, 蒋德明, 沈惠贤. 火花点火发动机压力循环变动的评价方法研究 [J]. 内燃机学报, 2000, 18(2): 171-174.

LI Xinghu, JIANG Deming, SHEN Huixian. Study on evaluated methods of pressure cyclic variation in spark ignition engines [J]. Transactions of CSICE, 2000, 18(2): 171-174.

HUANG Bin, HU Erjiang, HUANG Zuohua, et al. Cycle-by-cycle variations in a spark ignition engine fueled with natural gas-hydrogen blends combined with EGR [J]. Intentional Journal of Hydrogen Energy, 2009, 34(19): 8405-8414.

林志强, 苏万华, 万国强. 柴油引燃天然气发动机着火特性及其影响因素的影响 [J]. 燃烧科学与技术, 2003, 9(3): 234-238.

LIN Zhiqiang, SU Wanhua, WAN Guoqiang. Study on characteristics of ignition and misfire in the diesel/natural gas dual fuel engine [J]. Journal of Combustion Science and Technology, 2003, 9(3): 234-238.

何联格,左正兴,向建华. 气缸盖冷却水腔内两相流动沸腾传热仿真研究. 2013,47(1):21-26.

高广新,袁竹林,周阿朋,等. 二甲醚发动机燃料供给系统偶件间隙泄漏测量. 2012,46(11):12-16.

赵伟,舒歌群,张韦,等. 富氧燃烧对柴油机低温燃烧反应机理影响的数值分析. 2012,46(3):69-74.

盛新堂,高广新,吴国伟,等. 二甲醚发动机燃料喷射过程及其影响因素研究. 2012,46(1):9-12.

汪映,郭振祥,周杰. 预混充量压缩着火和直接喷射对发动机性能影响研究. 2011,45(3):44-47.

吴东垠,仝利娟,姚季,等. 乳化剂和分散相含量对乳化液黏度的影响. 2010,44(11):6-11.

汪映. 二甲醚中巴客车生命周期分析研. 2010,44(1):5-8.

朱瑞军,王锡斌,冉帆,等. EGR和冷EGR对柴油机燃烧和排放的影响. 2009,43(9):23-26.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Combustion Performance and Stability in Dual Fuel Engine with Different Pilot Diesel Injection Timings

Performance and Emission of Diesel Engine Operating on Diesel-Propane Blends

Effects of Fuel Injection Timing on Combustion and Emission Characteristics of a Diesel Engine Fuelled with Diesel-Propane Blends

Investigation of Dimethyl Ether Injection Process and Influencing Factors

Experimental Investigation on Emissions of a Spark-Ignition Engine Fuelled with Hydrogen Enriched Natural Gas

Related Author

曾科

苗海燕 1

王锡斌 1

李冲霄 1

黄佐华 1

马志豪 1

高广新 2

Related Institution

Internal Combustion Engine Research Institute, Xi'an Jiaotong University

西安交通大学动力工程多相流国家重点实验室

河南科技大学车辆与动力工程学院

江苏女神汽车集团

State Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University

⁰