Experimental Study on Pool Boiling Heat Transfer of R134a-Oil Mixture Outside Single Horizontal Enhanced Tubes

费继友 1; 2; 张定才 1; 李连生 1

您当前的位置：

首页 >

文章列表页 >

Experimental Study on Pool Boiling Heat Transfer of R134a-Oil Mixture Outside Single Horizontal Enhanced Tubes

更新时间：2025-12-08

- Experimental Study on Pool Boiling Heat Transfer of R134a-Oil Mixture Outside Single Horizontal Enhanced Tubes
- Vol. 42, Issue 5, Pages: 519-523(2008)
- 作者机构：
  
  1. 西安交通大学能源与动力工程学院,西安,710049
  2. 大连交通大学机械工程学院,大连,610028
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK172
- Online First：10 May 2008，
  
  Published：2008
- 稿件说明：
移动端阅览
费继友 1, 2, 张定才 1, et al. Experimental Study on Pool Boiling Heat Transfer of R134a-Oil Mixture Outside Single Horizontal Enhanced Tubes[J]. 2008, 42(5): 519-523.
DOI：

费继友 1, 2, 张定才 1, et al. Experimental Study on Pool Boiling Heat Transfer of R134a-Oil Mixture Outside Single Horizontal Enhanced Tubes[J]. 2008, 42(5): 519-523. DOI：

摘要

对3根高效强化管(E21、 E22、 E23)在饱和温度为5 ℃和10 ℃的工况下进行了水平管外含油R134a池沸腾传热的实验研究.实验结果表明:相对于光滑管

强化管E21、E22和E23的管内传热系数强化倍率分别为3.703、3.035和2.709; 在蒸发温度为5 ℃时

在不同的流速下

含油率为100×10

-6

的外表面传热系数比含油率为50×10

-6

的传热系数增加了3.7%～7.2%

而在10 ℃时增加了0.8%～10.9%.研究结果对于制冷系统中蒸发器的设计具有一定的参考作用.

Abstract

In this study

heat transfer coefficients were experimentally determined for three horizontal enhanced tubes(E21

E22

E23)with R134a-oil mixture. The evaporation temperature was 10 ℃ and 5 ℃

respectively and the water velocity inside enhanced tubes was ranged from 1.5 m/s to 3.5 m/s. The results show that compared with smooth tube the enhancement magnification of heat transfer coefficient inside E21

E22 and E23 is 3.703

3.035 and 2.709

respectively. The heat transfer coefficients outside the tubes with the oil concentration of 100×10

-6

increase by 3.7%-7.2% compared with those with oil concentration of 50×10

-6

at the same water velocities and the evaporation temperature 5 ℃

while by 0.8%-10.9% at the evaporation temperature 10 ℃.

关键词

Keywords

references

丁睿,郑钢,宋吉. 润滑油对管内沸腾换热影响研究综述[J]. 流体机械,2006,34(16):80-85.

DING Rui, ZHENG Gang, SONG Ji. Research review of lubricant oil's impact on in-tube flow boiling heat transfer [J]. Fluid Machinery, 2006,34(16):80-85.

SCHLAGER L M, PATE M B, BERGLES A E. Heat transfer and pressure drop performance of smooth and internally finned tubes with oil and refrigerant 22 mixtures [J]. ASHRAE Trans, 1989, 95: 160-169.

ECKELS S J, DOERR T M, PATE M B. Heat transfer coefficients and pressure drops for R2134a and an ester lubricant mixture in a smooth tube and a micro-fin tube [J]. ASHRAE Trans, 1998, 104: 366-375.

CAWTE H, SANDERS D A, POLAND G A. Effect of lubricating oil contamination on evaporation in refrigerants R12 and R22 [J]. Int J of Energy Research, 1996, 20(8):663-679.

ZURCHER O, THOME J R, FAVRAT D. Flow boiling and pressure drop measurements for R2134a/oil mixtures: evaporation in a plain tube [J]. HVACR Research, 1997, 3(1): 54-64.

严嘉,童明伟,杨鹏. HC290 含油工质在水平微肋管内沸腾换热特性及压降的实验研究 [J]. 制冷学报,2005,26(1):5-10.

YAN Jia, TONG Mingwei, YANG Peng. An experimental investigation on evaporation heat transfer and pressure drop of HC290-oil mixtures in a horizontal micro-fin tube [J]. Journal of Refrigeration, 2005, 26(1):5-10.

魏文建,胡海涛,丁国良,等. 含油制冷剂在小管径换热管内流动沸腾换热特性实验研究 [J].上海交通大学学报,2006,40(2): 286-290.

WEI Wenjian, HU Haitao, DING Guoliang, et al. Experimental study on the influence of oil on heat transfer performance of refrigerant flow boiling inside small tubes [J]. Journal of Shanghai Jiaotong University, 2006,40(2): 286-290.

WEBB R L, RUDY T M,KEDZIERSKI M A. Prediction of the condensation coefficient on horizontal integral-fin tubes [J].ASME Journal of Heat Transfer, 1985, 107(2): 369-376.

SUKHATME S P, JAGADISH B S, PRABHAKARAN P.Film condensation of R11 vapor on single horizontal enhanced condenser tubes [J]. ASME Journal of Heat Transfer, 1990,112(1): 229-234.

蒋能照. 新制冷工质热力性质图和表 [M]. 上海:上海交通大学出版社,1992.

杨世铭, 陶文铨. 传热学 [M].4版. 北京:高等教育出版社,2006.

GNIELINSKI V. New equations for heat and mass transfer in turbulent pipe and channel flow [J]. Int Chemical Engineering, 1976, 16(2): 359-368.

CHENG Bing, TAO Wenquan. Experimental study of R152a film condensation on single horizontal smooch tube and enhanced tubes [J]. ASME J Heat Transfer,1994,16(2): 266-270.

KLIME S J, MCCLINTOCK F A. Description of uncertainties in single sample experiments [J]. Mechanical Engineering, 1953,75(1): 3-9.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experimental Study on Start-up Process of Pulsating Heat Pipe

Experimental Study on the Effect of Elliptical Inlet Nozzle on Performance of Multi-Blade Centrifugal Fan

Experimental Study on New Variable Composition Heat Pump System

Experimental Study of Heat Transfer Effect on Oil-Free Scroll Air Compressor

Experimental Study on Pumping Behavior of Twin-Screw Multiphase Pump

Related Author

吴业正 1

任挪颖 1

丛伟 1

王瑞祥 1

徐荣吉 1

陈望明 2

毛义军 1

Related Institution

Department of Refrigerating and Cryogenic Engineering, Xi'an Jiaotong University

Institute of Refrigeration and Cryogenics, Zhejiang University

National Engineering Research Center of Fluid Machinery and Compressors, Xi'an Jiaotong University

Key Laboratory of Thermo-Fluid Science and Engineering of MOE, Xi 'an Jiaotong University

State Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University

⁰