Large-Eddy Simulation on Boundary Separation of High-Lift Low-Pressure Turbine Blade with Synthetic Jet Control

您当前的位置：

首页 >

文章列表页 >

Large-Eddy Simulation on Boundary Separation of High-Lift Low-Pressure Turbine Blade with Synthetic Jet Control

更新时间：2025-07-09

- Large-Eddy Simulation on Boundary Separation of High-Lift Low-Pressure Turbine Blade with Synthetic Jet Control
- Vol. 45, Issue 3, Pages: 58-64(2011)
- 作者机构：
  
  1. 西安交通大学能源与动力工程学院,西安,710049
  2. 上海电气电站设备有限公司,上海,201100
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK26
- Online First：10 March 2011，
  
  Published：2011
- 稿件说明：
移动端阅览
Large-Eddy Simulation on Boundary Separation of High-Lift Low-Pressure Turbine Blade with Synthetic Jet Control[J]. 2011, 45(3): 58-64.
DOI：

Large-Eddy Simulation on Boundary Separation of High-Lift Low-Pressure Turbine Blade with Synthetic Jet Control[J]. 2011, 45(3): 58-64. DOI：

摘要

为了研究合成射流对低压高负荷透平叶片边界层流动分离进行控制的效果及机理

采用大涡模拟方法对利用合成射流控制低压高负荷透平Pak-B叶栅内的非稳态流动分离特性进行了研究.在合成射流控制下的结果表明:Pak-B叶栅吸力面流动分离位置变化不大

再附位置明显提前

叶栅吸力面尾缘区域逆压梯度明显减小

总压损失系数降低

分离泡尺寸缩小; 叶栅吸力面大部分剪切层黏附于壁面

也未出现大尺度二维展向涡

静压脉动特征频率向高频转移

低频脉动幅值降低

大尺度涡旋结构发生变化.通过研究还发现:在吹气过程中

边界层外部高能流体被射流卷吸进入边界层内

边界层内流体能量增大进而抑制了分离; 在吸气过程中

射流孔上游区域边界层厚度减小

流速增大

从而抑制了下游流动分离.

Abstract

In order to understand the effect and mechanism of controlling blade boundary flow separation using synthetic jets for a high-lift low-pressure turbine(LPT)cascade

the large-eddy simulation(LES)method was adopted to investigate the unsteady separation flow characteristics of the LPT Pak-B cascade with and without flow control using synthetic jets. The results indicate that the separation location in the controlled case changes slightly but the reattachment location moves upstream significantly on the suction surface of the Pak-B blade. The adverse pressure gradient

total pressure loss coefficient and the size of separation bubble near the cascade trailing edge all decrease remarkably. On the suction surface of the blade

the most part of the shear layer attaches to the wall and the large-scale two-dimensional vortex does not exist. The spectrums of static pressure in the trailing edge of the Pak-B cascade clearly show the conversion of characteristic frequency to high frequency

the decrease of low frequency domain and variation of the large-scale vortex structure. In addition

in the blowing stage

the fluid with high energy out of the boundary layer are entrained into the boundary layer and the energy of the fluid inside the boundary layer increases to inhibit the flow separation; in the suction stage

the boundary layer in the upstream domain of the jet hole becomes thinner and the flow rate rises

inhibiting the flow separation downstream.

关键词

Keywords

references

赵洪雷,韩万金,谭春青,等.高负荷低压涡轮的多级气动优化设计[J].工程热物理学报,2008,29(9):1479-1482.

ZHAO Honglei, HAN Wanjin, TAN Chunqing, et al. Multistage aerodynamic optimization design of high load low-pressure turbine [J]. Journal of Engineering Thermophysics, 2008, 29(9):1479-1482.

HUANG J H, CORKE T C, THOMAS F O. Unsteady plasma actuator for separation control of low-pressure turbine blades [J]. AIAA Journal, 2006, 44(7): 1477-1487.

BYERLEY A R, STORMER O, BAUGHN J W, et al. Using gurney flaps to control laminar separation on linear cascade blades [J]. ASME Journal of Turbomachinery, 2003, 125(1): 114-120.

蓝吉兵,谢永慧,张荻. 低压高负荷燃气透平叶片边界层分离转捩数值模拟与流动控制 [J].中国电机工程学报, 2009, 29(26): 68-74.

LAN Jibing, XIE Yonghui, ZHANG Di. Numerical simulation and control of separated transition flows in high-lift low-pressure gas turbine cascade [J]. Proceedings of the CSEE, 2009, 29(26): 68-74.

蓝吉兵, 谢永慧, 张荻. 采用球窝控制边界层分离流动的大涡模拟 [J]. 西安交通大学学报, 2010, 44(9):27-32.

LAN Jibing, XIE Yonghui, ZHANG Di. Large eddy simulation for control of boundary layer separation with dimples [J]. Journal of Xi'an Jiaotong University, 2010, 44(9): 27-32.

LAKE J P, KING P I, RIVIR R B. Low Reynolds number loss reduction on turbine blades with dimples and V-grooves,AIAA-2000-0738 [R]. Reston, VA, USA:AIAA, 2000.

LAKE J P, KING P I, RIVIR R B. Reduction of separation losses on a turbine blade with low Reynolds number, AIAA-1999-0242 [R]. Reston, VA, USA: AIAA,1999.

ELDREDGE R, BONS J. Active control of a separation boundary layer with steady vortex generating jets-detailed flow measurements, AIAA-2004-751 [R]. Reston, VA, USA: AIAA, 2004.

VOLINO R J. Separation control on low-pressure turbine airfoils using synthetic vortex generator jets[J]. ASME Journal of Turbomachinery, 2003, 125(4): 765-777.

HANSEN L, BONS J. Flow measurements of vortex generator jets in separating boundary layer [J]. Journal of Propulsion and Power, 2006, 22(3): 558-566.

张攀峰,王晋军,冯立好.零质量射流技术及其应用研究进展 [J].中国科学:E辑, 2008, 38(3):321-349.

ZHANG Panfeng, WANG Jinjun, FENG Lihao. Advances in zero mass flux jet technology and applications [J]. Science in China Series:E, 2008, 38(3): 321-349.

ZHENG Xinqian, ZHOU Sheng, LU Yajun, et al. Flow control of annular compressor cascade by synthetic jets[J/OL]. ASME Journal of Turbomachinery, 2008, 130 [2008-03-24]. http:∥dx.doi.org/10.1115/1.2751147.

MATHIS R, DUKE D, KITSIOS V, et al. Use of zero-net-mass-flow for separation control in diffusing s-duct [J]. Experimental Thermal and Fluid Science, 2008, 33(1): 169-172.

YOU D, MOIN P. Active control of flow separation over an airfoil using synthetic jets [J]. Journal of Fluids and Structures, 2008, 24(8): 1349-1357.

SARKAR S. Effects of passing wakes on a separation boundary layer along a low-pressure turbine blade through large-eddy simulation [J]. Journal of Power and Energy, 2007, 221(4): 551-564.

RAVERDY B, MARY I, SAGAUT P, et al. High-resolution large-eddy simulation of flow around low-pressure turbine blade [J]. AIAA Journal, 2003, 41(3): 390-397.

LILLY D K. Models of cloud-topped mixed layers under a strong inversion [J]. Journal of the Royal Meteorological Society, 1968, 94(401): 292-309.

MATSUURA K, KATO C. Large-eddy simulation of compressible transitional flows in a low-pressure turbine cascade [J]. AIAA Journal, 2007, 45(2): 442-457.

DONOCAN J F, KRAL L D, Cary A W. Active flow control applied to an airfoil [C]∥36th Aerospace Sciences Meeting and Exhibit. Reston, VA,USA: AIAA, 1998:210.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Steady and Pulsed Vortex Generator Jets Control of Flow Separation in Rectangle Diffuser

Study on Effects of Double-Arc Non-Uniform Blades on the Flow Control and Aerodynamic Performance of Multi-Blade Centrifugal Fan

Unsteady Flow Control Mechanism of Synthetic Jet on a Low Pressure Turbine Blade

Noise-Reduction Mechanism of Bionic Coupling Blade Based on the Trailing Edge of Goshawk Wing

Study on the Special Vortical Structure Development During Flow Separation Control by VGJs in Boundary Layer of Flat Plate with Adverse Pressure Gradient

Related Author

张荻 1

樊涛 1

谢永慧 1

LIU Xiaomin

JIANG Jiwu

TIAN Chenye

MA Yanpeng

PENG Xiaokang

Related Institution

Midea Group Kitchen and Hot Water Division

School of Energy and Power Engineering, Xi’an Jiaotong University

Department of Fluid Machinery and Engineering, Xi'an Jiaotong University

Guangdong Sunwill Precision Plastics Co., Ltd.

School of Highway, Chang'an University

⁰