Numerical Simulation of Flow Inside Falling Film Evaporator with Horizontal Tubes Refrigeration System

阮并璐; 刘广彬; 赵远扬; 李连生

您当前的位置：

首页 >

文章列表页 >

Numerical Simulation of Flow Inside Falling Film Evaporator with Horizontal Tubes Refrigeration System

更新时间：2025-12-08

- Numerical Simulation of Flow Inside Falling Film Evaporator with Horizontal Tubes Refrigeration System
- Vol. 42, Issue 3, Pages: 318-322(2008)
- 作者机构：
  
  西安交通大学流体机械与压缩机国家工程研究中心,西安,710049
- 作者简介：
- 基金信息：
- DOI：
  CLC： TB657.5
- Online First：10 March 2008，
  
  Published：2008
- 稿件说明：
移动端阅览
阮并璐, 刘广彬, 赵远扬, et al. Numerical Simulation of Flow Inside Falling Film Evaporator with Horizontal Tubes Refrigeration System[J]. 2008, 42(3): 318-322.
DOI：

阮并璐, 刘广彬, 赵远扬, et al. Numerical Simulation of Flow Inside Falling Film Evaporator with Horizontal Tubes Refrigeration System[J]. 2008, 42(3): 318-322. DOI：

摘要

采用FLUENT两相流VOF模型

对制冷系统中水平管降膜式蒸发器内部流场进行了数值模拟

研究了蒸发器内部蒸发管的不同布管方式对蒸发器内部流场的影响.计算结果表明:由于蒸发器入口制冷剂液体的滴落速度较小

而蒸发器内部气体流速相对较大且流场不均匀

因此导致液体垂直下落过程中受流场的影响较大; 针对入口制冷剂流速不大的情况

预留水平的气流通道有助于改善蒸发器内部流场; 较大宽度的气流通道有助于蒸发器内部流场的优化

该研究中满液式蒸发所占的比重较大

所以上部预留较小宽度

下部预留较大宽度有利于整体流场的优化.

Abstract

Simulation on the inner flow field of a horizontal tubes of falling film evaporator in a refrigeration system was performed using two-phase flow model VOF in FLUENT

and the influence of different tube arrangements on the flow field was examined. The results show that the large vapor velocity and the non-uniform flow field inside the evaporator affect the distribution of liquid droplets significantly because of the small refrigerant liquid velocity. When the velocity of the refrigerant flowing into the evaporator is small

it seems more suitable to adopt the tube arrangement with horizontal vapor passages. It is likely that the tube arrangement with smaller space in the upper portion and larger space in the lower portion is more reasonable because of the large proportion of the vapor from flooded refrigerant inside the bottom of the evaporator.

关键词

Keywords

references

RIBATSKI G, JACOBI A M. Falling-film evaporation on horizontal tubes-a critical review [J]. International Journal of Refrigeration, 2005, 28: 635-653.

FUJITA Y, TSUTSUI M. Experimental and analytical study of evaporation heat transfer in falling films on horizontal tubes [C]∥Proceedings of the 10th international heat transfer conference. Brighton,UK:IChem E, 1994:175-180.

MOEYKENS S A, HUEBSCH W W, PATE M B. Heat transfer of R-134a in single-tube spray evaporation including lubrificant effects and enhanced surface results [J]. ASHRAE Trans, 1995,101(1):111-123.

HU X, JACOBI A M. The intertube falling film: mode effects on sensible heat transfer to a falling liquid film [J]. ASME J Heat Transfer, 1996, 118: 626-633.

MOEYKENS S A, NEWTON B J, PATE M B. Effects of surface enhancement film-feed supply rate, and bundle geometry on spray evaporation heat transfer performance [J]. ASHRAE Trans, 1995, 101(2): 408-419.

CHANG T B, CHIOU J S. Spray evaporation of R-141b on a horizontal tube bundle [J]. Int J Heat Mass Transfer, 1999, 42: 1467-1478.

ROQUES J F, THOME J R. Falling film transitions between droplet, column, and sheet flow modes on a vertical array of horizontal 19 FPI and 40 FPI Low-finned tubes [J].Heat Transfer Engineering,2004,24:40-45.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study of the Mechanism of Electrostatic Accumulation and Current Density Distribution Characteristics During Liquid Hydrogen Pipeline Transportation

Numerical Simulation of Space Charge Distribution Characteristics of Polyimide Materials under X-Ray Irradiation

Numerical Simulation Study on Geothermal Extraction Characteristics of Supercritical CO2 in Heterogeneous Fractures

Action Mechanism of Heat Transfer between the Working Medium and the Impeller on Aerodynamic Performance and Flow Characteristics of Radial Inflow Turbines with Supercritical Carbon Dioxide

Energy-Saving Control Study of R507A/CO2 Composite Refrigeration System based on Adaptive-Augmented Particle Swarm Optimization Algorithm

Related Author

SUN Wenhao

LIU Hongbao

WANG Lei

QING Ziyou

LI Zhuolun

MA Yuan

LI Yanzhong

ZHONG Hui

Related Institution

School of Energy and Power Engineering，Xi’an Jiaotong University

Aerospace System Engineering Shanghai

School of Electrical Engineering，Xi’an Jiaotong University

Northwest Institute of Nuclear Technology

Institute of Electronic Engineering，China Academy of Engineering Physics

⁰